I know it's bound to happen. I've got an oem tank in my 1975. With any less than ¾ a tank full of gas, I seem to get fuel starvation issues after entering a very hard right turn. I know there are companies that make accusumps for oil systems, is there such a thing for fuel systems? What am I looking at cost-wise for a baffled tank that has near-stock capacity and will fit in the normal tank location? Modify a stock tank somehow?
Budget is somewhere around $0, but I am posting to get ideas and suggestions for the near future.
The stock tank has a baffle in it....one big vertical one. Iffin the "green/blue/bondo rocket" is pulling that many "g's" in an autocross, I would check the door handles for asphalt scrapes.
Check the lines to the tank do you have them switched? Change fuel filter ASAP. Maybe moving dirt around in filter.
The baffle has been known to come adrift inside the tank. Might wanna take a look in there ................ The Cap'n
pull the cap and peak down there.... with a flashlight (not a match LOL)
you should see a cofee can looking thing down at the bottom by the pickup.......
AA
If the low fuel light is coming on at anything less than 1/4 even in high-G turns, something is wrong. I'll agree that the baffle has come loose, or the fuel level sender has gone wrong and you're not really filling the tank.
On my car (intact baffle, cleaned tank, good fuel sender), the light will blink on in long hard right-handers (like a freeway ramp) below 1/4 tank, but not above it. It won't stay lit when going straight until I'm down to R on the gauge. With the accordion-nozzle emissions thingies at the gas pump, if I let the nozzle hang the whole way into the tank, it usually shuts off at 2/3 to 3/4 tank, not full. If you're only getting 2/3 and your fuel level sender is hanging up in the tube (a common failure mode), you may actually have a lot less gas in the car than you think.
I also don't get fuel starvation in hard turns unless the tank is really empty. Look in the tank and see if the top of the baffle is exposed. You're below 2 gallons at that point.
btw, if the fuel lines on the EFI are switched, it won't run at all. Zero fuel pressure, as the fuel won't flow through the regulator backwards, it will just return to the tank.
Powered by Invision Power Board (http://www.invisionboard.com)
© Invision Power Services (http://www.invisionpower.com)