 Good news ...Bad news, Helo needed |
|
|
|
Porsche, and the Porsche crest are registered trademarks of Dr. Ing. h.c. F. Porsche AG.
This site is not affiliated with Porsche in any way. Its only purpose is to provide an online forum for car enthusiasts. All other trademarks are property of their respective owners. |
|
|
| simonjb |
 Nov 4 2018, 11:17 AM
Post
#1
|
|
KiwiMan  Group: Members Posts: 566 Joined: 18-October 16 From: Stamford, Connecticut Member No.: 20,505 Region Association: North East States 
 |
So the good news is that I managed to get the new engine started today. She fired right up after a crank or two and ran great!! First time in 2 years...
Then, I noticed the alternator light was on -RED. Then I noticed a bunch of smoke from the engine bay. Turned her off and...The red wire from the starter to the alternator was red hot and burning...it burnt all the way to the alternator from the starter....... The battery was also making strange noises....and was very warm When I got the engine the harness was already connected. I connected the longer end to the starter. and also plugged it in to the relay board     Sounds like something wasn't connected right? Perhaps the red wire wasn't connected correctly to the alternator? |
   |
 
|
  |
Replies
| ClayPerrine |
Nov 8 2018, 02:03 PM
Post
#2
|
|
Life's been good to me so far..... Group: Admin Posts: 16,312 Joined: 11-September 03 From: Hurst, TX. Member No.: 1,143 Region Association: NineFourteenerVille
|
That flat sided cover doesn't look quite right. I don't remember a flat side being on the alternator cover at all.
Let me look at my stash of alternator covers after work and get back to you. Clay |
|
|
|
| ClayPerrine |
Sep 10 2019, 08:02 AM
Post
#3
|
|
Life's been good to me so far..... Group: Admin Posts: 16,312 Joined: 11-September 03 From: Hurst, TX. Member No.: 1,143 Region Association: NineFourteenerVille
|
QUOTE(ClayPerrine @ Nov 8 2018, 03:03 PM)  That flat sided cover doesn't look quite right. I don't remember a flat side being on the alternator cover at all. Let me look at my stash of alternator covers after work and get back to you. Clay That is definitely not a factory 914 alternator cover. It may be from a bus. If it works and doesn't short the harness, I wouldn't worry too much about it. Clay |
|
|
|
Posts in this topic
simonjb Good news ...Bad news Nov 4 2018, 11:17 AM
Mike Bellis That would be a dead short to cause the burned wir... Nov 4 2018, 11:36 AM mepstein Glad it wasn't a whole lot worse. Nov 4 2018, 11:39 AM
wndsrfr
Glad it wasn't a whole lot worse.
As beautif... Nov 4 2018, 11:50 AM dlee6204 Was this a rebuilt alternator? Likely the stud te... Nov 4 2018, 01:06 PM North Coast Jim
Was this a rebuilt alternator? Likely the stud t... Nov 5 2018, 08:26 PM dr914@autoatlanta.com
Was this a rebuilt alternator? Likely the stud t... Nov 6 2018, 09:52 AM 72hardtop
Was this a rebuilt alternator? Likely the stud t... Sep 10 2019, 02:26 AM sixnotfour Clay wrote;
Hiya... Glad you are here. One thing t... Nov 4 2018, 01:07 PM simonjb
Clay wrote;
Hiya... Glad you are here. One thing ... Nov 4 2018, 01:18 PM ClayPerrine
Clay wrote;
Hiya... Glad you are here. One thing ... Nov 4 2018, 08:50 PM simonjb Yes, it was quite a scare and I was ready to pull ... Nov 4 2018, 01:14 PM JOEPROPER I've been trying to follow this build and lost... Nov 4 2018, 02:57 PM simonjb So I managed to get the alternator out..
As you ... Nov 5 2018, 05:53 PM mepstein We take our starters and alternators to a local ba... Nov 5 2018, 05:56 PM simonjb perhaps this is what happened ? Its the washer tha... Nov 5 2018, 06:03 PM Spoke How does that 2nd stud compare with a stock 914 al... Nov 5 2018, 07:17 PM dlee6204 I’ve also seen it before on a rebuilt unit where... Nov 6 2018, 06:23 AM simonjb So it looks like the post was not too high - rathe... Nov 6 2018, 10:50 AM simonjb Here is the solution...cut the edge off the washer... Nov 6 2018, 10:52 AM sixnotfour from samba
template for alternator gasket 02190363... Nov 6 2018, 02:42 PM simonjb
from samba
template for alternator gasket 0219036... Nov 6 2018, 03:50 PM mgphoto
from samba
template for alternator gasket 021903... Nov 28 2018, 12:13 PM simonjb So a nice package arrived today from Mr Bowlsby...... Nov 26 2018, 07:34 PM rgalla9146 I recently had this problem with a rebuilt alterna... Nov 26 2018, 09:24 PM sixnotfour :) Sep 6 2019, 03:06 AM dcheek This confirms what my daily driver mechanic sugges... Sep 12 2019, 04:11 PM mepstein We always take the alternators and starters to a l... Sep 12 2019, 04:26 PM |
1 User(s) are reading this topic (1 Guests and 0 Anonymous Users)
0 Members:
|
Lo-Fi Version | Time is now: 9th May 2025 - 10:07 AM |
Invision Power Board
v9.1.4 © 2025 IPS, Inc.